← NHTSA complaints

2004 SAAB 9-5 — ENGINE

fire · 2090819 · 2025-05-10

Vehicle

Make
SAAB
Model
9-5
Year
2004
Manufacturer
SAAB CARS USA, INC.
Component
ENGINE

Severity

Deaths
0
Injured
0
Fire
Yes
Crash
No
Police report
No
Medical attention
No
Vehicle towed
No

Narrative

I purchased my 2004 Saab 9-5 in 2023. I was under the impression that everything was running and that drivability was proper. When I attempted to drive the automobile it would start, idle 7 minutes and stall. It would not start again for about 35 minutes. I tried to use it, and this behavior continued. Often, in traffic it would stall while I was moving at low speed, and moderate speed: Without warning, it cuts out and won't start for 40 minutes. I have spent money with my mechanic, over $1,000. I personally bought many parts: MAF sensor, fuel pump relay, fuel filter, and fuel pump. I replaced the Coolant Sensor. After all this the vehicle still stalls 5 minutes after warmup. If it drives to warm up, it stalls and won't restart for 40 minutes. After I replaced the Crankshaft Position Sensor, (CPS), it has never restarted. I bought 3, one a Bosch branded model, and It has never restarted. Many other drivers complain in forums, like Saab Forums, that they are experiencing the same problems. As you know, stalling at highway speeds can cause death. Clearly the problems with the Saab motorcars, produced, owned, and sold through General Motors, are something that poses a hazard, and should be repaired at GM dealership's expense. P.S. The vehicle's immobilizer device has caused my vehicle to not start at all. The key fobs have stopped functioning at all. I replaced the batteries, and they won't connect to the engine. The vehicle will crank, but no start. Battery runs down, w

Source

Authoritative
NHTSA ODI Flat-File Downloads
ODI Number
11660144
Machine
JSON-LD · Markdown