NHTSA complaint: 2022 FORD EXPEDITION — SERVICE BRAKES
On Nov 22 I pulled over to the shoulder of a highway in the midst of a snowstorm to make a phone call. When I went to get back onto the highway, my vehicle lost all brakes...the brake pedal hit the floor...and I had a low-speed impact with a berm rising up to a driveway that intersected the shoulder. The vehicle had to be towed to a nearby dealer. The only mechanism to stop it on/off the tow truck was slamming transmission into park. Due to the storm, I had to spend the night in the vehicle in the freezing cold at the tow destination. The cause of the brake failure was determined to be a material defect of a rubber section of brake line deep in the engine compartment that burst, causing a loss of all brake fluid. It was repaired under warranty. I had just received the vehicle back from repairing the body damage to the bumper when the Ford brake line recall was issued. I believed that my incident in Nov was the result of the issue that resulted in the recall, and that surely the warranty repair would have thus resolved all related issues. That was not the case. When I brought the vehicle to Koons Ford Woodbridge four routine service, they found that it failed the brake line recall test and that the vehicle was unsafe to drive. However, they are not actively repairing it. In fact, the parts needed to repair don't exist. I'm told it will be 2-3 months before a part is even available. And they have failed to provide an any vehicle that can safely transport my fa
National Highway Traffic Safety Administration — Office of Defects Investigation