NHTSA complaint: 2013 HYUNDAI SANTA FE SPORT — ENGINE
I was driving on March 20, 2026 at about 12:00 PM when I suddenly noticed smoke, a strong gasoline smell, an oil smell, and a burning odor coming from the vehicle. I pulled over immediately because I believed the vehicle was unsafe and at risk of fire. The vehicle had to be towed. An independent repair shop later found a fuel leak at the high-pressure fuel line / fuel pump area, a loose ground wire on the right-hand side of the engine, a valve cover gasket leak, and engine timing chain noise. I was informed that gasoline had sprayed throughout the engine bay. This created an immediate fire hazard even though no actual fire occurred. This problem was especially concerning because the vehicle had been inspected and serviced by an authorized Hyundai dealer in December 2025, less than about 3,000 miles earlier. The loose engine ground wire and fuel leak raise serious concerns about vehicle safety and the adequacy of the prior inspection. I contacted Hyundai the same day and reported this as a fire-risk safety issue, but I did not receive timely assistance. Because immediate dealer service was not available, I had to authorize emergency repairs at a local shop for safety reasons. No warning lights were noted before the incident. The failure was confirmed by the repair shop.
National Highway Traffic Safety Administration — Office of Defects Investigation