NHTSA complaint: FREIGHTLINER FL60 — FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
BRAKES IN REAR OF TRUCK CONSTANTLY WEARING EXCESSIVELY. THIS CAUSES TRUCK NOT STOP PROPERLY WHEN THEY WERE APPLIED. BEEN IN SHOP NUMEROUS OF TIMES FOR REPAIRS THAT WOULD FAIL. REAR BRAKE PROBLEMS HAS NEVER BEEN CORRECTED TO SATISFACTION. LOST OF REVENUE TO DUE IN THE SHOP. *AK CONSUMER EXPERIENCED MANY PROBLEMS WITH BRAKING SYSTEM CALLED DURAPARK, AN ACCIDENT WAS CAUSED DUE TO FAULTY BRAKES, ALSO ABS LIGHT ILLUMINATED SEVERAL TIMES AND DEALER REPLACED ABS SENSORS, DEALER ALSO FOUND AIR IN BRAKING SYSTEM MORE THAN ONCE. DOOR PANELS AND LATCHES WERE FAULTY. DRIVER SEAT LUMBAR BROKE, DRIVER SEAT WOULD NOT LOCK IN PLACE. HEATER, AIR CONDITIONER, DEFROSTER FAULTY, DEALER FOUND BLOWER MOTOR FAILED AND HEATER CABLE OUT OF ADJUSTMENT. LOOSE CLAMPS CAUSED OIL LEAK, ENGINE HAD POOR POWER. POWER STEERING PUMP GASKET LEAKED. SYNCHRONIZERS WORE CAUSING GRINDING, CLUTCH REPLACED, DRIVESHAFT FAULTY, DIFFERENTIAL LEAK, TRANSMISSION OUTPUT SHAFT LEAK. POWER WINDOW CONTROL STUCK. ODOMETER ADDED A TENTH OF A MILE WHEN PARKING BRAKE WAS APPLIED. ELECTRICAL PROBLEMS INCLUDED: WIRE SHORTAGE, BAD GROUND TO DUMMER SWITCH, BATTERY BOX RUSTED, AND BATTERY COVER FELL OFF. WINDOW SEALS FAILED, WINDSHIELD WASHER HOSE PINCHED AND THE WIRING WAS CORRODED. SHOCKS LEAKED. PARKING BRAKE KNOB BROKE. HOOD HANLE NOT CENTERED, DEALER REALIGNED. FUEL INJECTION PUMP AND FUEL PUMP FAULTY. TEMP AND CHARGING SYSTEM GAUGES HAD LOOSE CONNECTION. DOME LIGHT ALMOST DISCONNECTED. DASH ASSEMBLY HAD
National Highway Traffic Safety Administration — Office of Defects Investigation